Bleeding the brake system of air without using the brake filling and bleeding device |
Special tools and workshop equipment required |
t
| Bleeding bottle (commercially available) |
Note t
| Bleeding the brake system on vehicles with ABS is undertaken in the same way as for vehicles without ABS. |
t
| On vehicles with load-dependent brake-power regulator, move the lever of the brake-power regulator while bleeding the rear wheel-brake. |
t
| While bleeding continuously check the brake fluid level in the brake fluid reservoir and top up brake fluid if necessary up to the „MAX“ marking. |
–
| Build up pressure in the brake system by pumping repeatedly the brake pedal. |
–
| Fit on hose of bleeding bottle. |
–
| Loosen the bleeder screw by pressing on the brake pedal and bleed. |
–
| Tighten the bleeder screw with the brake pedal pressed down. |
–
| If required, repeat this procedure until the brake system is bled fully. |
Note Repeat this procedure until the brake system is fully bled, i.e. until even the smallest air bubbles have escaped from the system. |
1.
| Rear right wheel-brake cylinder/brake caliper |
2.
| Rear left wheel-brake cylinder/brake caliper |
3.
| Front right brake caliper |
4.
| Front left brake caliper |
–
| After bleeding close the relevant bleeder screw and fit dust cap. |
Vehicles with ABS BOSCH 8.0, ABS BOSCH 8.2 and vehicles without ABS |
–
| Perform a test drive. While doing so, at least one ABS adjustment must be carried out on vehicles with ABS! |
Caution Before the basic setting is performed, first of all the brake system must be fully bled until even the smallest air bubbles have escaped from the system. |
The air bubbles would penetrate into the ABS hydraulic unit when performing the basic setting. |
It is very difficult to remove these air bubbles from the ABS hydraulic unit. |
|
Vehicles with ABS//TCS/ESP BOSCH 8.0 |
–
| Perform basic setting of vehicle diagnosis, measurement and information system -VAS- → Chapter. |
–
| Perform test drive with at least one ABS adjustment! |
Vehicles with ABS//TCS/ESP BOSCH 8.2i |
–
| Perform test drive with at least one ABS adjustment! |
|
|
|